The sight of a tug towing a barge is probably a very common sight one would observe along the Malacca Straits or even on waters surrounding South East Asia and Asian countries. So common that it may sometimes be seen as just another type of sea transportation mode which is considered relatively simpler, but at times and quite inaccurately, regarded as lower risk compared to transporting goods using larger vessel. The reality is far from these assumptions and reasons for this will be elaborated on further in this article.
Barges, on which cargoes are shipped, are usually non self-propelled and therefore dependent on a tug for propulsion; where the tug is the prime mover for the barge, connected to the barge using a towline. Distance between both can reach 200 metres and more.
Why is this method popular?
There are a couple of reasons that lead to barge shipments being so popular and common within the Asia Pacific region. Among them is accessibility advantage as tugs and barges are smaller with much lower draught compared to larger vessels, therefore able to access locations not accessible to large vessels. Another reason would be cheaper mode of transport as these vessels are much cheaper to operate and maintain, compared to larger ocean-going vessels. Others would include versatility in which to a certain extent, barges are almost like a general cargo vessel, able to transport a wide variety of cargo, albeit in much smaller quantities.
Types of configurations and arrangement
The most common configuration is the single tow, where one tug tows one barge. Another configuration is the tandem tow, also termed double tow, where one tug tows two barges, which possess higher risk compared to a single tow. Other types of configuration would be tandem and breasted tugs, where two tugs are used to pull one tow unit and termed according to the positioning of the tugs.
Common losses with typical attributable causes
Stranding and foundering are probably the most common losses experienced by tugs and barges.
This is usually caused by one or a combination of factors such as engine failure, underpowered tug, outdated navigation charts and towline or related tow gear failure. Capsizing are also commonly attributable to the some of the above factors and sometimes caused by inadequate stow and/or securing of cargo which compromises stability or structural failure.
Another common accident would be collision with other vessels. This is commonly caused by crew negligence, poor navigation watch keeping, inadequate display of lights and shapes by tug and/or barge and defective navigation aids.
Others include fire losses, typically caused by poor housekeeping, unsafe practice, crew negligence, inadequate/poorly maintained fire-fighting equipment and/or nature of cargo (inherent vice). In certain regions, piracy and hijacking is also a common occurrence; this can be caused by poor watch-keeping, poor voyage planning and/or very little or no anti-piracy measures.
Characteristics of high risk tugs and barges:
There are a number of characteristics that would increase the probability of a loss materialising. One of these is when a tug or barge is unclassed or classed by a classification society that is not a member of the International Association of Classification Society (IACS). This would likely lead to the vessel not complying with international maritime standards. Another would be the over age, especially if unclassed/non-IACS classed, where the vessel is not maintained and operated to the required standards, which among others, could lead to loss of propulsion or structural failure.
Another characteristic is when the tug does not have the minimum power to tow the barge, in turn causes the tug to lose control of the barge especially during rough sea conditions. Other characteristics would be little or no Port State Control (PSC) Inspections history, owners/operators with poor reputation, vessel flagged in little known or PSC blacklisted flags.
What should be checked before shipping on barges?
As a minimum, always request for:
When in doubt, always refer to your insurer for specialist advice and assistance.
This content is brought to you by Chubb Insurance Australia Limited (“Chubb”) as a convenience to readers and is not intended to constitute advice (professional or otherwise) or recommendations upon which a reader may rely. Any references to insurance cover are general in nature only and may not suit your particular circumstances. Chubb does not take into account your personal objectives, financial situation or needs and any insurance cover referred to is subject to the terms, conditions and exclusions set out in the relevant policy wording. Please obtain and read carefully the relevant insurance policy before deciding to acquire any insurance product. A policy wording can be obtained at www.chubb.com/au, through your broker or by contacting any of the Chubb offices. Chubb makes no warranty or guarantee about the accuracy, completeness, or adequacy of the content. Readers relying on any content do so at their own risk. It is the responsibility of the reader to evaluate the quality and accuracy of the content. Reference in this content (if any) to any specific commercial product, process, or service, and links from this content to other third party websites, do not constitute or imply an endorsement or recommendation by Chubb and shall not be used for advertising or service/product endorsement purposes. ©2020 Chubb Insurance Australia Limited ABN: 23 001 642 020 AFSL: 239687. Chubb®, its logos, and Chubb.Insured.SM are protected trademarks of Chubb.